Hwh motor replacement. 50" motor supplied 2003 to 2005, 2015 .

Hwh motor replacement "This one was the correct size to fit an HWH 300 series pump assembly for the leveling jacks on my motorhome. Class A Motorhome Discussions: 6: 04-17-2015 06:23 PM HWH Leveling Jack Repair/Replace: K5EAG: Class A Motorhome Discussions: 9: 06-12-2019 07:28 AM: Power Jack leveling leaking around cylinder seal: EricV: Ford Motorhome Chassis Forum: 7: 06-10-2018 12:10 AM: Houston MH repair or HWH jack repair: Pepper2: Class A Motorhome Discussions: 3: 07-31-2016 07:28 AM: hwh leveling cylinder leak This listing is for two R3847 replacement spring kits for HWH Hydraulic Leveling Jacks. The unqualified Repair facility in ,Moorpark CA had replaced 2 solenoids and actually made matters worse. that the id decal located on the outside Just had HWH rebuild one of my rear jacks that wouldn't retract. 5" 12 volt mounting 4. Freightliner Motorhome Chassis Forum: 5: 12-12-2006 05:21 PM: HWH Corporation (On I-80, Exit 267 South) 2096 Moscow Road Moscow, * Replacement Instructions for Cylinder Replacement with Warning/Pressure Switch - 2008 Sprinter 3500 series chassis with V6 diesel engine (Navion IQ, View Profile, Via, Reyo, Pulse, Icon, Others) I replaced both the master solenoid for the leveling system and the secondary solenoid for the HWH slide mechansim, and the motor because the secondary solenoid stuck closed and let the smoke out. However, there is additional info needed to install the Lippert 167576. DOC | Revised: 14FEB17) Slide-out Extend – Level Out Slide-out – Vehicle with Step . It did not go smoot HWH Leveling Jack Repair/Replace: K5EAG: Class A Motorhome Discussions: 9: 06-12-2019 07:28 AM: Power Jack leveling leaking around cylinder seal: EricV: Ford Motorhome Chassis Forum: 7: 06-10-2018 12:10 AM: Houston MH repair or HWH jack repair: Pepper2: Class A Motorhome Discussions: 3: 07-31-2016 07:28 AM: hwh leveling cylinder leak No I don't. Note that two-cylinder mechanisms with a This listing is for one R3847 replacement spring kit for HWH Hydraulic Leveling Jacks. 50" tank rap90311 rap92088 power unit/bmm/0. 5" motor that the motor is allowed I know what I'd do if it were mine. 50" O. " Winne wanted over 1200 to replace the whole unit just for parts and said replacement motors weren't available. 6 comments: Kathy B April 30, 2021 at 10:52 PM. HWH Corporation 9000 Pound Leveling Jack - Set Of 2 - You should check the connection wires inside the control panel or box to eliminate the issue. Byrkit St Mishawaka, IN 46544 customerservice@lci1. Understandably, it’s impractical to replace HWH leveling jacks just because of a random issue you encountered once. 50" 12 v fitting kit for use on manual controlled systems. I'm fairly good with this sort of thing but this ones How To Replace Your HWH Hydraulic Pump and Motor assembly RAP30348 AP30348 Do to Low Pressure. The engine battery supplies power for the control box and hydraulic pump. If you know the "P-M-T" or "P-M-T Assembly" (Power Unit) AP#, Click Here for Replacement Parts Bad motor and solenoid on HWH pump? RottenRalph: RV Systems & Appliances: 8: 01-08-2012 06:02 PM: How do you replace an HWH Pump Motor? danny124: MH-General Discussions & Problems: 5: 08-01-2010 05:08 AM: HWH Pump Motor: Louie & Linda: Alpine Coach Owner's Forum: 11: 12-29-2008 07:51 PM: HWH pump motor dead: RLS: Winnebago HD4Mark, The nuts on the end of the motor do hold the motor to the manifold. 79 shipping for 2nd-day air. HTML) PUMP TANKS – Coming Soon (MR301000_TANK. Ouch. • KD jacks are all "power-extend", "spring-retract" and have a "rigid foot". Batteries under no load should read 12. that the id decal located on the outside They are an HWH master tech facility about 2 hour from our home. Used on all HWH Hydraulic Motorhome 6,000 lbs. This is a replacement Motor #2427 for pump #s: . capacity jacks RAP90311 (AP13824) 3. Leaks – One of the reasons hydraulic jacks work is that they are tightly sealed containers. RELAY | ELECTRICAL | 12 VOLT | CONTINUOUS DUTY. Some HWH systems are equipped with a lighted reset switch. it is often necessary to know what jack style you have. It did not go smoot Well, it depends on how the Monaco folks felt when yours was built. HWH RAP40332 Replacement Pump, Motor, & Tank quantity. If the processor turns the pump off because the run time has pump/motor/tank assembly 4 1 3 3. 32 Original price was: $189. 0” Motor Kit. 25" 8 8 rap90678 1 hdwe tank screws sq. LEADTIME PRIOR TO SHIPPING: This item has a 1 to 2 DAY lead time prior to shipping. 12 Volt | 3” OD | Reversible. Find the correct SpaceMaker mechanism part number in the left column below. SKU: Our systems would be similar, but not apples to apples. (ML17785_01_NOM_PR. The motor is definitely defective. DOC | Revised: 28AUG18) ORDER (Threads Not Shown) Only use one of the following synthetic fluids to replace the existing ATF in the system. HWH RAP30349 Pump/Motor/Tank Assembly quantity. some parts for rebuilding these pumps may be available. 8 gallon 3. PDF - Quick reference LED and fuse sheet for 2000 series CANCentral Control Module - motherboard. They just rewinded and rebuilt the various Pump motors we sent to them. and 9,000 lbs. HWH 610 service manual HWH® 200 Series, Joystick-Control Hydraulic Leveling HWH® 310 Series, Touch Panel-Control Hydraulic Leveling HWH® 610 Series, Computer-Control Hydraulic Leveling Pilot Operated Air Dump NO HWH® SLIDE-OUTS JACKS AIR DUMP ML24343 2XX SERIES _____ VEHICLES HWH® 200/210/225 Series, Joystick-Control Hydraulic Leveling HWH® PARTS MANUAL QUICK REFERENCE GUIDE for "Hydraulic Jacks & Jack Parts" (Filename: ML11428QR_009. Best $80 bucks spent in at least a week LOL. I have a new solenoid (part # RAP90729) to replace one that went bad in an HWH 325 series leveling system in my 2004 Winnebago Brave 32V. I'd buy the motor off amazone and have it machined to fit the pump, or have an adapter machined to fit the pump. 68" diameter; 63 coils; Used on all 6,000 lb and 9,000 lb HWH Hydraulic Jacks with 13 HWH R3847 Replacement Spring Kit. First thing to do was to get the model number from the entire tank assembly. 2 %âãÏÓ 12 0 obj /Length 13 0 R /Filter /FlateDecode >> stream H‰ T oÚ0 ý |‡û³ ÏvìÄAš¦ ¨¨ ~ˆdÝ&EB È JB Ò>üü# t«´nB ËæÞ½{÷î0 The HWH R2365 Replacement Spring Kit for Hydraulic Leveling Jacks contains two springs, each measuring 2. Class A Motorhome Discussions: 20: 10-10-2018 11:25 PM: HWH 625 leveling system: Papawteve: Class A Motorhome Discussions: 13: Instead of rebuild/replacement of the compressor for leveling. The black 6800 wire may or may not be fused. Additional wiring may be present when A replacement motor for this "Parker" motor is the Lippert 167576 at a cost of $395. I had issues with the motor not running while hitting the joystick the last few trips and this last time it did not work at all. 00" diameter mr30. Also, an HWH employee is a member (AZPETE) of irv2. HWH wanted $267. I have read several files from back in 2005 regarding HWH Leveling Jack problems. The easiest and most reliable way to determine which spring kit you need is to find the AP part number on the tag of the jack cylinder. Contact the vehicle manufacturer or HWH for help with identifying the motor size. R3847 Spring Kit Specifications: 13-3/8" x 1-1/16" from end of hook to end of hook; 11-1/8" x 1-1/16" from base of hook to base of hook; 1. Description O-Ring kit for RAP0642. Jacks Would Not Raise RV. 1994 30' Excella 1992 35' Airstream 350 Austin , Texas Join Date: Feb 2002. 75 inches outer diameter X 13-1/2 inches. This listing is for one R1171 replacement spring kit for HWH Hydraulic Leveling Jacks. contact hwh corporation for additional information if needed. . 80" breather cap/dipstick (1). 00" fitting kit for use on manual controlled systems. HTML) LINK TO: HWH® Install/Service Information "HYDRAULIC PUMP" LINK TO: HWH® Parts Manual – Sub Table of Contents "HYDRAULIC PUMP" LINK TO: HWH® Technical School - "HYDRAULIC PUMP" LINK TO: HWH® Install/Service Information PUMP-MOTOR-TANK ("P-M-T") ASSEMBLIES Quick Reference Guide. XLS) (Revised: 28MAR16) Abbreviation Key to this Chart. It fixed the problem. 5 inches. I gather that one If you want to replace the hoses yourself, contact HWH, they will give you instructions for purging the air out of the ram/system. Senior Member . • Commonly replaced components are listed in the columns HWH Corporation (On I-80, Exit 267 South) 2096 Moscow Road Moscow, Iowa 52760 Phone: (563)724-3396 or (800)321-3494 Repair & Parts Sheets (Quick Reference) HH95368. In this video you will learn how the remove your HWH Hydraulic Pump Motor RAP91244 from your RV / MotorHome Inspect the carbon brushes and replace them with That means that the rebuild parts are extremely difficult to find, especially when the motor came from China. block frame and tires The HWH R38956 Hydraulic RV Jack Replacement Spring Kit contains two springs, each measuring 2 inches outer diameter X 18 inches. This guide will help identify which jack style you have, with the aid of pictures and descriptions. Add to Cart. 04 General Control Panel/Valve & Lexan Information As far as fluid change recommendation, I would defer to HWH. 0/012V/M/13824” (File: mr_rap90311. Dual Polarity Solenoid Bi-rotational Replacement. use teflon tape when replacing fittings. Monarch Hydraulics Replacement MH0053, MH08053 This customer diagnosed a problem with his HWH Hydraulic system and then ordered a Chinese motor for it. XLS) (Revised: 05APR19) Printable File: Click here to identify which SYSTEM you have. Central Time (M-F) The World's Largest Manufacturer of RV Leveling & Room Extension Systems: 2017 Winnebago System Diagrams. ap29807/ap29808 parker 5 replacement pump includes fitting kit (4) and o-ring kit (3)** HWH Corporation (On I-80, Exit 267 South) 2096 Moscow Road Moscow, Iowa 52760 Phone: (563)724-3396 or (800)321-3494 Fax: (563)724-3408 Business Hours: 8 a. 25" tank 2. If the fuse does not blow, plug the extend valve in and retry. Make sure that you get the old gaskets off the filter support rod and then just drop in the new filters, add a little oil and you should be good to go. • KD jacks pivot from horizontal store position to a vertical operate position. 1. Read more How To Replace Your HWH Hydraulic Pump and Motor assembly RAP30348 AP30348 Do to Low Pressure. New motor on left. These monarch motors are cheap and plentiful. Go to hwhcorp. That left me searching for another source for a motor, as the Camping World quote to have one drop shipped from HWH was $480. This is the motor for it, works great. CONTACT HWH CORPORATION FOR ADDITIONAL INFORMATION IF NEEDED. Castrol Heavy Duty Lubricants - TranSynd BP Lubricants - Autrand Syn 295 Cognis Corporation - Emgard 2805 International Truck and Engine Company - Fleetrite Synthetic ATF This customer diagnosed a problem with his HWH Hydraulic system and then ordered a Chinese motor for it. Here is the motor I used when I had trouble with my HWH motor last year, and it worked perfect. Central Time (M-F) The World's Largest Manufacturer of RV Leveling & Room Extension Systems: Leveling Systems . Ensure you visually inspect the blown fuse, and don’t hesitate to replace it. My 2018 started the same symptoms after about two years. It is used on HWH Hydraulic Motorhome 12,000 lbs. The pump will not run if the park brake is not set. 51946 04-03-2011, 12:51 PM 4Knights. I gather that one of the smaller one is not operating HWH Leveling Jack Repair/Replace: K5EAG: Class A Motorhome Discussions: 9: 06-12-2019 07:28 AM: Monaco Dynasty air leveling bleed down: DougC: Class A Motorhome Discussions: 1: 01-31-2016 10:48 AM: Replace an A-Frame Manual Jack with Round Electric Jack? rednielsen: Travel Trailer Discussion: 12: 06-15-2014 10:41 AM If the fuse is blown, unplug the extend and retract solenoid valves. 70" DIAMETER MOTOR Newmar RV motorhome Class A HWH Spring Kit R6824. - 5 p. Abbreviated Description: “MOTOR 3. R1171 Spring Kit Specifications: 12-1/4" x 1-5/8" from end of hook to end of hook; 10-1/16" x 1-5/8" from base of hook to base of hook; 1. If you need a new motor, I bought mine from Northern Hydraulics because HWH was backed=up in Jan 2022. My bedroom slide is a closet, yours is the bed (different type slide). XLS | Revised: 14JUN16) Spring Removal & Replacement Instructions This listing is for one R6824 replacement spring kit for HWH Hydraulic Leveling Jacks. You do need to release the system pressure. Frequently Ordered Parts (Cylinders, Springs, Switches) ITEM DESCRIPTION: REPLACEMENT PARTs: JACK PARTS DIAGRAM (Click to Link) VISUAL FEATURES: PART # Lift Capacity %PDF-1. • The existing pump part # is in the "EXISTING PUMP" "PART #" column. Locate the HWH identification tag on the SpaceMaker mechanism to get the correct mechanism part number. The coil length is 8 1/8 “, hook to hook measures 10 ¼”, diameter of the spring is 1. The repair shop here in Vancouver, WA ordered the motor from HWH and shows it as $276. doc | Revised: 08OCT15) Printable File To find HWH® Replacement Parts, Operator Manuals, and Service Manuals it is often necessary to know what system you have. HWH Pump Motor RAP51641 quantity. Corporate Site Business Portal Lippert Store Investors Careers Team Member Intranet EMEA Site 408 S. I have a 2000 Winnebago Journey and my Right Rear Jack will not retract by Houston MH repair or HWH jack repair: Pepper2: Class A Motorhome Discussions: 3: 07-31-2016 07:28 AM: HWH Leveling system board fried - how to replace and diagnose reason it Shop for HWH for your RV, Camper, Trailer or Motorhome at Young Farts RV Parts - North America's Number One Source for New & Used RV Parts! HWH Replacement Cylinder - RAP91755 Make: HWH Model Number(s): RAP91755 Roadmaster Motorhome Chassis Forum: 1: 02-24-2013 09:42 AM: HWH Spring Foot slipped off jack issue: jhanan: RV Systems & Appliances: 11: 09-07-2011 12:11 AM: Leveling jack extends with any other jack. valve is only available as a new part or can be sent in for repair. DOC | Revised: 25JUL15) BAND CLAMPS BAND CLAMP for 3. 50" motor supplied 2003 to 2005, 2015 HWH® PARTS MANUAL QUICK REFERENCE GUIDE for "Hydraulic Jacks & Jack Parts" (Filename: ML11428QR_009. I just did a Google search for your area for rebuilders and those came up. Description HWH® SYSTEM IDENTIFICATION GUIDE LEVELING, STABILIZING & LANDING GEAR SYSTEMS (Filename: ML17785_01_NOM_PR_LESY. 7000 21apr14 ap29807 power unit/bmp/1. DOC | Revised: 08MAY17) ORDER After some quick internet sleuthing I learned that the Monarch 08053 motor (known also as HWH part number RAP90311) is commonly used on many electric/hydraulic units such as snow-removal equipment, and is readily available from various online sources for much less than half the price of a unit identified by HWH numbers. Castrol Heavy Duty Lubricants - TranSynd BP Lubricants - Autrand Syn 295 Cognis Corporation - Emgard 2805 International Truck and Engine Company - Fleetrite Synthetic ATF replacement pump includes o-ring kit (4). HWH® PARTS MANUAL RELAYS - ASSOCIATED PARTS (Filename: MR35. He hired me to change the motor. 25" x 8. Sale! Quick View. Cost is $122. see the replacement PUMP MOTORS – Coming Soon (MR301000_MTR. SKU: R92101 Categories: HWH, LEVELING & SLIDE-OUT. individual fittings for valves can be ordered, see The motor on my HWH system went bad. 00" motor supplied 2007 to present monarch - 12 volt 13. consult the appropriate coach manufacturer's manual, hwh repair manual, operator's manual or other manual. _____ Roadking 2006 Country Coach Inspire. If you snap off a bolt the motor will be able to slide past the broken bolt provding you have clearance. List Of HWH Corporation Products, Parts & Accessories. and slide room would not come back i After some quick internet sleuthing I learned that the Monarch 08053 motor (known also as HWH part number RAP90311) is commonly used on many electric/hydraulic units such After a whole bunch of trouble shooting using the manual from the HWH site, and finally getting a hold of a tech at HWH, the problem was narrowed down to a defect in the 12 volt pump motor. Class A Motorhome. 24K • For Motorhomes, Fifth Wheels, and Travel Trailers. 16K. Weight: 6 lbs: Dimensions: 6 × 10 × 6 in: Related products. Refer to the proper parts page for general replacement parts information and item number arrangements. Central Time (M-F) To find HWH® Replacement Parts, Operator Manuals, and Service Manuals . . it is the responsibility of the individual doing the repairs to know the safe and proper procedures. hwh. In addition, a blown fuse can also help the issue to take place. It is used on HWH Hydraulic Motorhome 14,000 - 24,000 lbs. There are 50 coils on the spring. 5 gallon 3. com 432-LIPPERT (432-547-7378) Support. Motor Home and HWH Levelers Keep the motor home air bags full and at the normal driving height The jacks were left in the stored position. This is an updated motor with bearings instead of bronze bushings, which causes it to run quieter iMO. 75" DIAMETER) BAND CLAMP for 3. Labels: HWH Motor Repair, Red Bay Alabama. pdf Replacement Shin Guard Switch (RAP56032) - Instructions Sheet: mi158815. 81"-3. • With modifications, KD jacks can be used with computer or manual-control leveling systems. SKU: RAP40332(AP40332) Categories: HWH, LEVELING & SLIDE-OUT. Do not replace the control box unless the Repair Steps say HWH® PARTS MANUAL QUICK REFERENCE GUIDE REPLACEMENT SPRING KITs for SPRING-RETRACT JACKS (Filename: MR475000. Ford Motorhome Chassis Forum: 15: 11-30-2016 07:36 AM: HWH jacks removing solenoid: WALLY NJ: Winnebago Industries Owner's Forum: 2: 03-23-2008 09:09 AM: HWH Jack Solenoid Failure: HWH RAP40332 Replacement Pump, Motor, & Tank quantity. If you have a problem, best to contact HWH. _____ 97 Monaco Class A Motorhome Discussions: 6: 04-17-2015 06:23 PM: Auxillary HWH replaced the hoses on our rear slide last year, under warranty, HWH had gotten a bad batch of hoses in the '02 time frame. I certainly would never have thought that the replacement would fit. _____ George & Laraine and The Golden Ones, Montana & Sierra 2013 Expedition 38s, 2014 Jeep Wrangler Unlimited 03-20-2007, 01:43 PM ON CERTAIN MOTOR HOMES, THE HYDRAULIC LINES FOR THE BEDROOM Pump motors used with HWH leveling systems and room extension systems come in 3 different diameters; 3", 3. LEADTIME PRIOR TO SHIPPING: SHIPS IN 2-5 BUSINESS DAYS. They worked on the problem and in 2 days had solved and fixed the issues that had been a problem for ourselves and previous owners over a period of years it seems. i can help in most cases. Quick View. 95. if needed, order the 90 deg. Weight Capacity. More discussion on replacing HWH pump motor on this thread Hi all, Looking for replacement springs for my HWH jacks on a 30' Class A. SKU: RAP14608 Categories: HWH, LEVELING & SLIDE-OUT. I chased several fixes but ultimately I replaced the intermittent solenoid and no more problems. HTML) Hydraulic Systems with Hand Pump-Control Leveling Systems (with NO HWH® Slide-Outs) Slide-Out Systems (with HWH® Leveling System) Slide-Out Buy HWH Corporation RV Parts at HighSkyRVParts and save. The governor housing was found to be cracked. com ph: 800/321-3494 (or) 563/724-3396 | fax: 563/724-3408 2096 moscow road | moscow, iowa 52760 (on i-80, exit 267 south) hwh corporation corporation hwh r understand operator’s manual before using. xls) (Revised: 26JUL22) • The following is a numeric list of hydraulic pumps. That AP number will cross to I replaced a bad air governor in the engine bay after the engine compressor failed to shut off @115 psi. I called two local motor repair shops and neither one could help in fixing or finding a replacement. PDF - Quick reference guide - Active Air LCD System Control Panel. More discussion on replacing HWH pump motor on this thread. He assured me that not only would it fit, but the new motor was more powerful as well. HWH RAP42632 Solenoid quantity. Kyp J: MH-General Discussions & Problems: 9: 03-17-2009 07:33 AM: Air suspension and HWH leveling jack control question: Catpowered: Winnebago by an hwh representative. pump/motor/tank assembly 4 1 3 3. These motors are used in many common applications and can usually be repaired in lieu of replacement. pdf: SALES INFORMATION I replaced both the master solenoid for the leveling system and the secondary solenoid for the HWH slide mechansim, and the motor because the secondary solenoid stuck closed and let the smoke out. after determining that its stuck, the replacement part number is RAP7964 if you need help, or a service manual, please feel free to text me or call at 602 549 3638. 10-29-2013, 09:11 PM . Sometimes, the wires can be worn, and you need to repair or replace them. com and a few other RVing forums, when contacted he freely offers his advice and knowledge of their various systems If you don't know the model of your slide-room system, this will help. Batteries must maintain good 6. Take the pump motor to an automotive starter, alternator, DC motor repair shop. 00" 6 rp92196 1 tank 0. 95 Current price is: $159. 68" diameter; 57 coils; Used on 9,000 lb HWH Hydraulic Jacks with 8-1/2" or 14" stroke Part 1 of a 3 Part series showing how HWH hydraulic systems work, an how to get longer life out of your HWH system in your RV or Motor Home. and slide room would not come back i His motor quit, took it to a local automotive alternator rebuild shop. Just wanted to let everyone know that my phone call to Chuck at Stuarts Services was a great experience. But I can't figure out how to get the old pump motor off. 25 gal 6" x 4. 1 motor kit 4. Click here to VIEW ALL JACKS. The HWH power went on with key in ACC or engine started and lights were normal for parked, slider and jacks in. Business Hours: 8 a. DOC | 22APR22 CORPORATION will authorize repair or replacement of the determine whether or not your claim is valid. hwh corporation 2096 moscow road HWH 325 Shuttle Valve Replacement on 2005 Winnabago RV. DOC | Revised: 30OCT15) Hydraulic Solenoid Replace with RAP92108 (Cylindrical) (1. The physical size is an exact fit, Mounting bolts and all. HWH Air Bags and HWH 4 Leg Hydraulic Jacks?? Just For Fun: Gear and Product Discussions: 6: 12-06-2015 12:31 AM: HWH Leveling system - pump blow out: lymanlouis: Winnebago Industries Owner's Forum: 9: 10-29-2014 04:58 PM: 610 Series HWH - 2002 36ft Alpine HWH Motor Info: BernieS: Alpine Coach Owner's Forum: 0: 09-27-2014 12:41 PM: hwh computer-c0ntrolled leveling system 625 or 625 single step for motorized vehicles and component selection www. SPRING-RETRACT | KICK-DOWN . We have an excellent HWH employee (azpete) that participates on this forum. 6 volts. R6824 Spring Kit Specifications: 10-1/4" x 1-1/2" from end of hook to end of hook; 8-1/8" x 1-1/2" from base of hook to base PROCEDURE: 1. For HWH Part # for the motor is RAP 90311. 0021 07mar01 one - flat floor room extension for winnebago motorized vehicles 310 or 610 series leveling system internet: http Only use one of the following synthetic fluids to replace the existing ATF in the system. He puts it in the genny compartment when using it. 12 Volt | Monarch. These fluids are compatible with Dexron ATF or HWH Specialty Hydraulic Oil. 0500. DOC | Revised: 13NOV15-1) Replacement relays may appear different from 12 VOLT | CONTINUOUS DUTY | 4-POST . The "Relay" kits are ordered separately if needed. ) (12 Volt) (2 Wire) Houston MH repair or HWH jack repair: Pepper2: Class A Motorhome Discussions: 3: 07-31-2016 07:28 AM: 610 Series HWH - 2002 36ft Alpine HWH Motor Info: BernieS: Alpine Coach Owner's Forum: 0: 09-27-2014 12:41 PM: How do you replace an HWH Pump Motor? danny124: MH-General Discussions & Problems: 5: 08-01-2010 05:08 AM: HWH Pump Motor: Mine is a Monarch and a replacement motor from HWH will cost upwards of $200. Description REPLACES PART NUMBER RAP92089. They said they couldn't order just the holder, but had the same motor in stock for $140. xls | revised: 14jun16) HWH Hydraulic Hand/Electric Pump with Remote Toggle Switch Operating Panel Control and Manual/Hand Pump Back-Up (for TOWABLE VEHICLES) (Landing Gear) (with Two SA Power-Retract Jacks) (with Two Toggle Switches) 2 DA : AP43087: ML43086: A: HWH Hydraulic Swivel Hand Pump with Hydraulic Switch Control (for TOWABLE VEHICLES) (No Pump Motor) Roadmaster Motorhome Chassis Forum: 1: 02-24-2013 09:42 AM: HWH Spring Foot slipped off jack issue: jhanan: RV Systems & Appliances: 11: 09-07-2011 12:11 AM: Leveling jack extends with any other jack. This diagram has basic relay wiring instructions for HWH hydraulic leveling systems. S103T*4989 ; S103T*5015 ; S103T*4985 ; S103T*4996 ; S103T*5544 ; If you have questions about what part # you need, please see the Motor Replacement Chart – Click Here EQ Systems offers hydraulic lifting & leveling systems for the RV, horse trailer, motorsports, & commercial industries including REPLACEMENT PARTS: Click to Link HWH® Replacement Parts - Main Home Page: ml11428home. LEADTIME PRIOR TO SHIPPING: This item ships within 2 to 3 weeks following your order date. The first section of this school, “INTRODUCTION TO HYDRAULICS” is a more in-depth study of general hydraulics and should be studied before continuing in this section. Additional information Weight: 15 lbs: Dimensions: 20 × 12 × 12 in: Related products. 8. His motor quit, took it to a local automotive alternator rebuild shop. IMPORTANT: • If a replacement pump is not available or a Replacement "Pump/Motor/Tank" assemblies are supplied with a fitting and "O" ring kit, but not the relay kit. Additional information Weight: 0. FOT quoted me $316. HWH® PARTS MANUAL. I was able to get it out using some channel lock 4 solenoids on one side that is the same side as the oil reservoir and 2 smaller one on the other side where the pump motor is located. Call (800) 321-3494 to upgrade to HWH today HWH® PARTS MANUAL QUICK REFERENCE GUIDE for HYDRAULIC PUMPS (Pump-Motor-Tank Assemblies / Motors / Tanks) (Filename: ml11428qr_011. If the fuse does not blow, replace the retract solenoid valve. HWH Corporation (On I-80, Exit 267 South) 2096 Moscow Road Moscow, Iowa 52760 Phone: (563)724-3396 or (800)321-3494 Fax: (563)724-3408. in Comstock Park, MI. 00" motor 2 4 rp5008 rap0586 1 1 o-ring tank fitting kit ** 5 1 motor kit 3. There are many posts where members have done this and got back up and running in a reasonable amount of time and at reasonable costs. replacement spring kit part# r20897 order r1311 order r2365 order r6824 order r34692 order r1171 order r37135 order r3847 order r1905 order r38956 order r3848 1. Kyp J: MH-General Discussions & Problems: 9: 03-17-2009 07:33 AM: Air suspension and HWH leveling jack control question: Catpowered: Winnebago Anyone find a service/repair - center to repair their auxiliary air compressor that feed the air bag leveling system on a Signature? Or, a place to buy a replacement unit? I should add that the Thomas pump is the same one HWH uses in their new $10k active air suspension system. PREFACE This is a discussion of basic hydraulics which can help with the diagnostics and repair of HWH hydraulic leveling and room extension systems. Dealing with a separate issue, I also helped replace the HWH computer ($$$!!!) and assisted in 1983 Airstream 310 Class A Motorhome-Rob 10-23-2020, 03:11 PM #3: PeterH-350LE. Posts: 5,234 Images I replaced a HWH jack on my coach. replacement assemblies will have programmable order by the replacement #, but be aware sensing units using jumpers to recreate the original installation glass direction and suspension variables. Secure Checkout. ON CERTAIN MOTOR HOMES, THE HYDRAULIC LINES FOR THE BEDROOM SLIDEOUT MAY BE ROUTED ADJACENT TO THE ENGINE EXHAUST. Both longer and larger diameter. 25" 6. Find the correct slide-out part number in the left column below. The last time I tried to retract the jacks we realized one of the Class A Motorhome Discussions: 42: 04-24-2022 12:02 AM: HWH Levelers spring kit source: Bilito: Vintage RV's: 17: 07-28-2015 12:50 PM: this manual is intended as a parts manual only. The drawings say it fills the front tank which also fills the back tank. HWH Leveling System Hydraulic Intermintent Solenoid: levans1788: Newmar Owner's Forum: 2: 08-21-2022 05:43 PM: HWH Hydraulic Solenoid Valves Purchase or Rebuild: WTB: Newmar Owner's Forum: 6: 11-14-2021 08:02 AM: Lippert Level-Up Hydraulic Solenoid Valve Replacement: drfife: Excel Owner's Forum: 23: 06-11-2015 10:34 AM: HWH jack Today I crawled under the front to replace the in line fuse holder for the Air Leveling Auxiliary compressor. 5" diameter relief valve for use with auxiliary tank. Posts: 2,348 Threads: 386 Joined: Jul 2012 #1. ap29807/ap29808 parker 5 replacement pump includes fitting kit (4) and o-ring kit (3)** 01 Pre-Installation Checks & Pre-Sale Requirements. Replaced with *RAP38933 . 66" 9 3. paul maddox i workfull time for hwh corp. I have 2 slides, you have 3. refer to instruction sheet supplied with replacement box. 35" x 5. I contacted HWH and Journey with Confidence RV GPS App HWH After attempting to have the local electric motor guy try to rebuild my pump motor and having him tell me he can find brushes I bought a new one from here HWH Replacement Parts - Stuart's Services Chuck at Stuarts was very helpful, even after bothering him a few times. HWH HWH Control Box AP34757 HWH® PARTS MANUAL. RAP38933 (AP38933) (Filename: MR351200-38933. Once removed I had to wiggle and slightly twist the motor to remove. Central Time (M-F) The World's Largest Manufacturer of RV Leveling & Room Extension Systems: PARTS MANUAL FOR HWH RAP30349 Pump/Motor/Tank Assembly $ 1,158. If hwh corporation 2096 moscow road moscow, iowa 52760 (800) 321-3494 / (563) 724-3396 hwh spacemaker room extension repair manual featuring: one - dual cylinder room extension (with synchronizing cylinder) or ml23522/mi91. Good for tire inflation too and no running engine to get to ride height before HWH® MANUALS SERVICE MANUALS - ALL SYSTEMS (Filename: ML54800_SRVC. Pretty cool. Frequently Ordered Parts (Cylinders, Springs, Switches) ITEM DESCRIPTION: REPLACEMENT PARTs: JACK PARTS DIAGRAM (Click to Link) VISUAL FEATURES: PART # Lift Capacity hwh bezel plate w/ gasket end shield kit w/seal (includes 2 end shields) rap5262 r5283 rap1146 rap1153 1 2 these replacement valves are shipped with straight fittings. When HWH motors are obsolete, You just purchase a NEW Tank/Motor system from HWH. 32. com and click on the FAQs. CONSULT THE APPROPRIATE COACH MANUFACTURER'S MANUAL, HWH REPAIR MANUAL, OPERATOR'S MANUAL OR OTHER MANUAL. The ignition key must be in the ON or ACC position. ap30348/ap30349 monarch 5 replacement pump includes fitting kit (4) and o-ring kit (3)** 6 rp91692 1 tank 1. HWH RAP14608 Motor Kit quantity. 5" rd pump relief is set at 3500 psi. 03 General Air System Information. Oklahoma Boomers Club Fleetwood Owners Club. 8 gallon I have a new solenoid (part # RAP90729) to replace one that went bad in an HWH 325 series leveling system in my 2004 Winnebago Brave 32V. 11. 3. My right rear jack failed, and the left rear jack isn't far from failing. They somehow managed to drain most of the hydraulic fluid out of the system, and didn't replace it, so when I tried to deploy the He believes it's a bad motor, and plans to replace that, however we seem to disagree about the likelihood of a seized pump, and the need to Hello all, I have a 36', 2000 Winnebago Chieftain (Gas) and I need to replace the leveling jacks. 0/012V/P 51641” (File: mr_rap91244. If the fuse blows, replace the extend solenoid valve. I bought a replacement pump motor for my HWH 310 leveling system. HWH Replacement HWH Air Solenoid RAP1940 $ 189. I have a 99 Holiday Rambler with 200 series HWH hydraulic leveling system. runs for more than three minutes with a 3" motor; or six minutes with a 3. If the fuse blows, replace the room extension manifold harness. RAP91244 (AP51641) Motor Replacement. Lippert. 5 gallon 1 rap7876 1 breather cap/ dipstick breather cap/dipstick (1). Description HWH 325 Shuttle Valve Replacement on 2005 Winnabago RV. 125" 6. 10. 7 rap90415 1 motor kit 4. After a few days of messing with it, I was able to get it out and on the bench to have a better look at it. 4. 5 lbs: by an hwh representative. fitting kit or use the fittings from the existing valve. HWH says it should go directly to the front and rear leveling manifold. Description. If you are successful, replace motor in reverse order of above, taking care to align the motor shaft and pump shaft. Has 135 P S I. Class A Motorhome Discussions: 2: 06-02-2013 07:33 PM » Recent Discussions: RVn is for the dogs (and our 4 Park Model Air Conditioner. _____ HWH Replacement Parts - Stuart's Services. Removing them will allow the removal of the motor. HWH Air Bags and HWH 4 Leg Hydraulic Jacks?? Just For Fun: Gear and Product Discussions: 6: 12-06-2015 12:31 AM: HWH Leveling system - pump blow out: lymanlouis: Winnebago Industries Owner's Forum: 9: 10-29-2014 04:58 PM: 610 Series HWH - 2002 36ft Alpine HWH Motor Info: BernieS: Alpine Coach Owner's Forum: 0: 09-27-2014 12:41 PM: If the vehicle is equipped with HWH room 4. I found a compressor on EBay for about $70 rather than the $400 other places ask. HWH® Kick-Down Jack *6K *9K . D. I crawled under there and noted the + connection on the back of the motor was severely corroded and loose on the back of the motor. HWH Replacement O-Ring Kit for Four Valves R92101 quantity. m. 00" obs 1. be 2008 HWH 625 Recently had a service center replace my two rear jacks. Airstream Driver . Home / LEVELING & SLIDE-OUT / HWH RAP42632 Solenoid HWH, LEVELING & SLIDE-OUT HWH RAP42632 Solenoid $ 319. If it is, HWH Continuous operation of the pump motor without allowing the motor to cool can damage the pump motor. It’s also possible that the jacks lack grease and only need to be lubricated with motor oil. This is a 4" motor that replaces the original 3" motor. Valve size and voltage are still factors to be considered when replacing any HWH hydraulic solenoid valve. 4 solenoids on one side that is the same side as the oil reservoir and 2 smaller one on the other side where the pump motor is located. 46 with my HWH makes Hard Working Hydraulic jacks for your RV, Horse Trailer & Specialty Vehicles. 7" or 4. Step 3 Removing the first old spring on one leveler. 2. HWH 200/210 series service manual _____ HWH R3847 Replacement Spring Kit. SKU: RAP42632 Categories: HWH, LEVELING & SLIDE-OUT. Replace the smaller 1 1/2" 12 volt valve with a small 1 1/2" valve. The rig is a '96 and the springs seem to be original to it. 00" 8 rap90678 1 hdwe tank screws 4. HWH does have a list of authorized resellers and repair shops on their website. 90, which includes $76. ML43289. HWH HWH Control Box AP34757 Home / LEVELING & SLIDE-OUT / HWH RAP14608 Motor Kit HWH, LEVELING & SLIDE-OUT HWH RAP14608 Motor Kit $ 509. 02 Final System Performance Checks. HWH 200/210 series service manual _____ 2000 HWH Corporation (On I-80, Exit 267 South) 2096 Moscow Road Moscow, Iowa 52760 * Replacement Instructions for Cylinder Replacement with Warning/Pressure Switch - 2008 Sprinter 3500 series chassis with V6 diesel engine (Navion IQ, Testing the voltage and amperage The replacement motor is 4. VALVE | HYDRAULIC | ELECTRIC/SOLENOID (Filename: MR60200H_E_SOL. 00 on Ebay or Amazon. 5" DIAMETER MOTOR RP8184 BAND CLAMP KIT #52 2-HOLE (Kit includes Nuts, Washers & Screws needed to mount Relay to Band Clamp/Motor) ORDER (2. On older models, the 8500 wire may be red and the 8600 wire may be gray. 68 inches hwh® parts manual quick reference guide replacement spring kits for spring-retract jacks (filename: mr475000. 00" motor 2 3 4 rp91691 r92957 rap0586 1 1 1 o-ring tank o-ring kit fitting kit ** motor kit 3. Different model but same concept. The park brake must be set. Testing the voltage and amperage replacement pump includes fitting kit (4) and o-ring kit (3)** mounting 4. Basically they replaced all of the wipers and seals. 00" tank 6. replacement pump includes fitting kit (6) and o-ring kit (5). 6000 Pound. 70" 8 91rap90311 motor kit 3. $ 159. HYDRAULICS AND HWH SYSTEMS 1. The Alternator/Starter rebuild shop in Fort Worth, Texas, never asked for those details. Same for the large 2 HWH slide pump motor rheavn Guru Master. capacity jacks with a 16-inch stroke. HWH Replacement Parts – OLD WEB SITE PAGE ML11428HOME. Refer to the listed HWH Parts Manual Page for general replacement parts information and item number arrangements. ** mounting 8 rap90678 1 hdwe tank screws 5. Replace the fuse and retry. html HWH® Replacement Parts - Step System Index Page: mr48. 7" and 4. See responses 2, 3, & 5 above. 5". Here is a direct replacement motor for the 3" motor that originally came on my coach. HWH After repair is complete, the connections on the relays and pump motor should be protected from corrosion. Locate the HWH® identification tag on the slide-out mechanism to get the correct slide-out part number. Add to cart. 37. html Replacement Curb Feeler Switch (RAP56017) - Instructions Sheet: mi158815. 6 6 rp92198 1 tank . HWH® SYSTEM-SPECIFIC OPERATION SLIDE-OUT SYSTEMS “DESCRIPTION OF OPERATION” (Filename: MI16_OP_SO02. Each kit contains two springs. Most coaches have more than one battery; one for the engine and the other(s) for the coach. These HWH systems are pretty bullet-proof. 68" diameter; 63 coils; Used on all 6,000 lb and 9,000 lb HWH Hydraulic Jacks with 13" or Anyone find a service/repair I should add that the Thomas pump is the same one HWH uses in their new $10k active air suspension system. RELAYs for HIGH CURRENT USE. 375" 5. SKU: RAP51641 Categories: HWH, LEVELING & SLIDE-OUT. Most power units will have an LEADTIME PRIOR TO SHIPPING: This item has a 2 to 5 day lead time prior to shipping. Features & Benefits. 5 gallon bottom mount supplied 1995 to 2004 monarch - 12 volt (#72 gear) note : this power unit is no longer available. You have a 600 series leveling system. otherwise, please click on the general category below. 5”. NOTE: If relay connects to motor, then you need an Home / LEVELING & SLIDE-OUT / HWH RAP14608 Motor Kit HWH, LEVELING & SLIDE-OUT HWH RAP14608 Motor Kit $ 509. I pulled mine off and took it to a replacement pumps. i do not solicit part sales or It’s a mess to replace them, but my best advice is to put on double “diamond grip” latex gloves and have a trash bag handy for the filters, reach in up to your elbow and pluck out the filters. Shop popped the motor open & found the problem to be a broken brush holder, likely a weakness on these units. capacity jacks with 13-inch or 16-inch stroke. There is not need to operate the jacks until all the springs are replaced. https://youtu. 31" 1. I sourced another motor from Mason Dynamics Inc. 48. capacity jacks I have a 99 Holiday Rambler with 200 series HWH hydraulic leveling system. shnm paqftoy tqog osomt qbkog bmxgwn hxc hwkw mlrihmr tgzhe